Product ID:DY-CHECK/FLURO-CHEK NAD DEVELOPER PSU
MSDS Date:08/24/1993
FSC:6850
NIIN:00-145-0255
Kit Part:Y
MSDS Number: BVGHD

TURCO PRODUCTS, INC.

7300 BOLSA AVE
WESTMINSTER, CA 92684-3600
US

Emergency Phone: 714-387-6200

Info Phone: 714-890-3600

Preparer: UNKNOWN.

Cage: 0BYN5

TURCO PRODUCTS, INC. DIVISON OF ELF ATOCHEM NORTH AMERICA

PHILADELPHIA, PA 19103-3222 US

Telephone: 215-419-7890

Cage: 61102

DICHLOROFLUOROETHANE

CAS: 1717-00-6

RTECS: KI0997000

Fraction By Weight: 40%

CALCIUM CARBONATE

CAS: 471-34-1

RTECS: FF9335000

Fraction By Weight: <5.0%

ISOPROPYL ALCOHOL (SARA III)

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 15%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM/500STEL;9394

1,1,1,2-TETRAFLUOROETHANE

CAS: 811-97-2

ALUMINUM HYDROXIDE

CAS: 21645-51-2

RTECS: BD0940000

Routes of Entry: Inhalation:YES Skin:NO Ingestion:NO
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:TARGET ORGANS:EYE, SKIN, RESPIRATORY &
GI TRACTS. ACUTE- EYE/SKIN:MAY CAUSE SEVERE IRRITATION.
INHALE:MODERATE TO SEVERE IRRITATION, HEADACHE, NAUSEA.
ORAL:MODERATE TO SEVERE IRRITATION OF GI TRACT. H ARMFUL IF
SWALLOWED. MAY CAUSE CARDIAC IRRITABILITY, CARDIAC ARRYTHMIA.
CHRONIC- LIVER & KIDNEY DAMAGE.
Explanation of Carcinogenicity:NONE
Effects of Overexposure:IRRITATION OF EYES, SKIN, RESPIRATORY AND
GASTROINTESTINAL TRACTS, NAUSEA, VOMITING
Medical Cond Aggravated by Exposure:HEART DISEASE, RESPIRATORY
DISORDERS, LIVER AND KIDNEY DISORDERS. THIS MAY BE FURTHER
AGGRAVATED BY ALCOHOL ABUSE.

First Aid:CALL A DOCTOR IF SYMPTOMS PERSIST. EYE:IMMEDIATELY FLUSH WITH
WATER FOR 15 MINUTES, HOLDING EYELIDS OPEN. SKIN:WASH WITH SOAP &
WATER. INHALED:REMOVE TO FRESH AIR. PROVIDE CPR/OXYGEN IF NEEDED.
ORAL:D O NOT INDUCE VOMITING EXCEPT ON ADVICE OF COMPETENT MEDICAL
PERSONNEL. IF VICTIM IS CONSCIOUS, DILUTE BY GIVING LARGE AMOUNT OF
MILK OR WATER. CALL A PHYSICIAN/POISON CONTROL CENTER IMMEDIATELY.

Flash Point:NONE
Extinguishing Media:WATER FOG, CARBON DIOXIDE OR DRY CHEMICAL
Fire Fighting Procedures:WEAR NIOSH-APPROVED SELF-CONTAINED BREATHING
APPARATUS OPERATED IN THE POSITIVE PRESSURE MODE. USE WATER SPRAY
TO COOL FIRE-EXPOSED CONTAINERS.
Unusual Fire/Explosion Hazard:CONTENTS UNDER PRESSURE. HEATING ABOVE
120F MAY CAUSE CONTAINER TO BURST. MAY DECOMPOSE TO TOXIC GASES.

Spill Release Procedures:WEAR PROTECTIVE EQUIPMENTS. VENTILATE AREA.
REMOVE WITH INERT ABSORBENT COMPOUND. PUT INTO CONTAINER. DISPOSE
AS HAZARDOUS WASTE. RELIEVE PRESSURE ON LEAKING CONTAINERS BY
IMMEDIATE USE OR EMPTY BY SP RAYING ONTO ABSORBENT MATERIALS.
Neutralizing Agent:NOT RELEVANT

Handling and Storage Precautions:STORE IN COOL, DRY AREA BELOW 120F. DO
NOT PUNCTURE OR INCINERATE. HEAT FROM SUNLIGHT, STOVES, HOT WATER
COULD CAUSE CONTAINER TO BURST.
Other Precautions:"EMPTY" CONTAINERS MAY RETAIN RESIDUE AND CAN BE
DANGEROUS. KEEP OUT OF REACH OF CHILDREN. WASH THOROUGHLY AFTER
HANDLING AND BEFORE EATING OR DRINKING. DO NOT BREATHE VAPORS. DO
NOT TAKE INTERNALLY. KEEP AWAY FROM SOURCES OF EXCESSIVE HEAT

Respiratory Protection:IF TLV IS EXCEEDED, USE NIOSH-APPROVED
SELF-CONTAINED BREATHING APPARATUS WITH FULL FACE PIECE, OPERATED
IN POSITIVE PRESSURE MODE.
Ventilation:LOCAL AND MECHANICAL EXHAUST RECOMMENDED.
Protective Gloves:NEOPRENE, VITON
Eye Protection:CHEMICAL SAFETY GOGGLES & FACESHIELD
Other Protective Equipment:EYE WASH STATION, SAFETY SHOWER, LONG SLEEVE
AND LONG PANTS, BOOTS
Work Hygienic Practices:OBSERVE GOOD PERSONAL HYGIENE PRACTICES AND
RECOMMENDED PROCEDURES.
Supplemental Safety and Health
KEY1:J7. THIS PRODUCT IS A KIT CONSISTING OF THREE PARTS. PENETRANT HAS
PNI A; REMOVER HAS PNI B AND DEVELOPER HAS PNI D, SAME NSN. FORMULA
FOR DEVELOPER CHANGED. FOR PREVIOUS FORMULATION, SEE PNI C, SAME
NSN.

HCC:V2
NRC/State Lic Num:NOT RELEVANT
Boiling Pt:=48.9C, 120.F
B.P. Text:APPROX.120F
Vapor Pres:APPROX 300
Vapor Density:>1
Spec Gravity:1.12
Evaporation Rate & Reference:>1 (N-BUTYL ACETATE=1)
Solubility in Water:APPRECIABLE
Appearance and Odor:RAPIDLY DRIES TO WHITE POWDERY COATING WHEN
SPRAYED; ALCOHOL ODOR
Percent Volatiles by Volume:95

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS, STRONGLY HEATED ACTIVE METALS, STRONG ACIDS
Stability Condition to Avoid:TEMPERATURES ABOVE 120F
Hazardous Decomposition Products:CARBON MONOXIDE, CARBON DIOXIDE,
OXIDES OF NITROGEN AND CHLORINE, HYDROCHLORIC, HYDROFLUORIC ACIDS,
OTHER TOXIC GASES

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH ALL APPLICABLE
LOCAL, STATE AND FEDERAL REGULATIONS. RECYCLE OR REUSE IF POSSIBLE.
IT MAY BE NECESSARY TO EMPTY SPRAY CANS AND PUNCTURE THEM BEFORE
DISPOSAL. TRIPLE RINSI NG MAY ALLOW DISPOSAL AS NONHAZARDOUS WASTE.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.